國外使用AF泡沫泵的案例與使用概況

英國和加拿大約有60%~70%的浮選廠采用乙基、異丙基和戊基黃藥等兩種或多種捕收劑組合添加。日本有的金選廠用208號黑藥與仲丁基鈉黃藥(301 號黃藥)作為組合捕收劑，浮選含金礦石的效果很好。
    俄羅斯研制了太陽油作為浮金的鋪助捕收劑與黃藥組合使用。據報道，用黃藥浮選(銅和鉛的)硫化礦過程中，添加非極性油,如錠子油、變壓器油、工業潤滑油等，能強化浮選過程，并明顯提高工藝指標和降低極性捕收劑的用量。俄羅斯的研究表明，用撒哈林島原油或變壓器油取代部分丁基黃藥后，可提高金的浮游活性。試驗得出:如果兩種捕收劑溶液分別進行準備，而在加入礦漿前一起攪拌，則精礦質量還可得到更大改善，如果將油先加入礦漿中，它對丁黃藥的吸附會產生不利影響。無論是添加變壓器油還是原油都會在黃藥浮金時產生附加疏水效應，而與巰基捕收劑在金上的吸附量是否增加無關，這顯然是因?yàn)榉菢O性捕收劑改善了礦粒向氣泡附著條件，也改善了巰基捕收劑在金粒上固著的條件。
    采用20%的巰基捕收劑和85%~ 95%脂肪酸捕收劑，在pH5~8的條件下，可從氰化處理后的尾礦中或低品位金礦中浮選殘留金或自然金。最佳的捕收劑用量為227~ 1360g/t。采用這種浮選工藝的優點是:即使原礦(氰化法處理后的殘?jiān)?/span>)的含金量變化較大，也能維持高水平的效率。曾對僅含金0. 6~1g/t的尾礦進行處理，表明采用此法可使金富集到每噸精礦含金量為4.8~7. 2g，且回收率高達89%。

法國介紹了鉀基黃藥與疏基苯并唯常組合浮選薩爾西涅礦床的含金毒砂礦石，砷和金的試驗回收率分別達到93%和90.5%時，可獲得合砷25.5%和含金19.28g/t的精礦。常規組合捕收劑也能得到相近的回收率，但最終精礦品位較低，含砷為23%，含金17. 5g/t。
    日本報道，選別含銀AF泡沫泵硫化礦時，使用美氰皮公司的31號黑藥和242號黑藥組合，以及黃藥與氨基酸或氨基乙磺酸[NH2(CH2)2SOs]組合。

The case and application of AF foam pump abroad
About 60% - 70% of flotation plants in the UK and Canada use ethyl, isopropyl and amyl xanthate as collectors. Some gold concentrators in Japan use 208 black medicine and SEC butyl sodium Xanthate (301 yellow medicine) as a combined collector, which has a good effect on Flotation of gold bearing ores.
Russia has developed a combination of sun oil as a collector aid and xanthate for floating gold. It is reported that adding non-polar oil, such as spindle oil, transformer oil and industrial lubricating oil, in the flotation process of sulfide ore (copper and lead) with xanthate can strengthen the flotation process, obviously improve the process index and reduce the amount of polar collector. Russian research shows that the floating activity of gold can be increased by replacing part of butyl xanthate with Sakhalin crude oil or transformer oil. The results show that if the two collector solutions are prepared separately and stirred together before adding slurry, the quality of concentrate can be further improved. If the oil is added into slurry first, it will have a negative impact on the adsorption of xanthate. No matter transformer oil or crude oil is added, there will be additional hydrophobic effect when the xanthate floats gold, which has nothing to do with the increase of the adsorption capacity of mercapto collector on gold. Obviously, this is because the non-polar collector improves the conditions for the attachment of ore particles to bubbles and the fixation of mercapto collector on gold particles.
With 20% sulfhydryl collector and 85% - 95% fatty acid collector, the residual gold or natural gold can be floatated from the tailings or low-grade gold ore after cyanide treatment under the condition of ph5-8. The best amount of collector is 227 ~ 1360g / T. The advantage of this flotation process is that it can maintain a high level of efficiency even if the gold content of raw ore (residue after cyanidation) changes greatly. The tailings containing only 0.6-1g/t of gold have been treated. The results show that the gold can be enriched to 4.8-7.2g/t concentrate by this method, and the recovery rate is as high as 89%.
France introduced the flotation of gold bearing arsenopyrite from salsinine deposit by the combination of potassium based xanthate and dibenzo only. When the recovery of arsenic and gold reached 93% and 90.5% respectively, the concentrate containing 25.5% arsenic and 19.28g/t gold could be obtained. However, the final concentrate grade is relatively low, with arsenic content of 23% and gold content of 17.5g/t.
Japan reported that when the silver containing AF foam pump was selected for the sulfide ore, the combination of the No. 31 black drug and No. 242 black drug combination of the United States cyanide company and the combination of xanthate and amino acid or [NH2 (CH2) 2SOs] were selected.